行业新闻
  • 您现在的位置:首页 > 新闻资讯 > 行业新闻 >
  • 无菌室缓冲间无菌室装修设计
    来源:http://www.jnyhrs.com 浏览: 发布日期:2021-12-13
    缓冲间需3-5平方米,可建在准备室外或无菌操作室外,应保持清洁无菌;备有鞋架和衣帽挂钩,并有清洁的实验用拖鞋、已灭菌过的工作服;墙顶用1-2盏紫外灯定时照射,对衣物进行灭菌。 缓冲间更好也安一盏紫外线灭菌灯,用以照射灭菌。缓冲间的门应该与接种室的门错开,两个门也不要同时开启,以保证无菌室不因开门和人的进出带进杂菌。
    The buffer room needs 3-5 square meters, which can be built outside the preparation room or sterile operation room, and should be kept clean and sterile; Equipped with shoe racks and coat hooks, clean experimental slippers and sterilized work clothes; The top of the wall is regularly irradiated with 1-2 ultraviolet lamps to sterilize the clothes. It is better to install an ultraviolet sterilization lamp in the buffer room for irradiation and sterilization. The door of the buffer room should be staggered with the door of the inoculation room, and the two doors should not be opened at the same time, so as to ensure that the sterile room will not bring in miscellaneous bacteria due to the opening of the door and people's access.
    总体要求:
    General requirements:
    1.应安装独立的送排风系统以控制无菌室气流方向和压力梯度。应确保在无菌室时气流经操作区流向排风口。
    1. An independent air supply and exhaust system shall be installed to control the air flow direction and pressure gradient in the sterile room. Ensure that the air flows through the operation area to the exhaust outlet when in the sterile room.
    2.送风口和排风口的布置应该是对面分布,上送下排,应使无菌室内的气流死角和涡流降至更小程度。
    2. The air supply and exhaust outlets shall be arranged opposite to each other, with upper air supply and lower air discharge, so as to minimize the air flow dead angle and vortex in the sterile room.
    3.送排风系统可以采用回风系统。
    3. The air supply and exhaust system can adopt the return air system.
    无菌室装修
    4.无菌室的送风应经初、中、高三级过滤。
    4. The air supply of the sterile room shall be filtered at the primary, medium and high levels.
    5.无菌室的外部排风口应远离送风口并设置在主导风的下风向,应有防雨、防鼠、防虫设计,但不影响气体直接向上空排放。
    5. The external exhaust outlet of the sterile room shall be far away from the air supply outlet and set in the downwind direction of the main wind. It shall be designed to prevent rain, rats and insects, but it will not affect the direct discharge of gas to the air.
    6.空气过滤器应安装在送风管道的末端。
    6. High efficiency air filter shall be installed at the end of air supply pipe.
    7.通风系统、空气过滤器的安装应牢固,符合气密性要求。过滤器在更换前应消毒,或采用可在气密带袋中进行更换的过滤器,更换后应立即进行消毒或焚烧。每台过滤器安装、更换、维护后都应该进行无菌室空气检测以确保其性能。
    7. The installation of ventilation system and high efficiency air filter shall be firm and meet the air tightness requirements. The high-efficiency filter shall be disinfected before replacement, or the filter that can be replaced in the air tight belt bag shall be disinfected or burned immediately after replacement. After the installation, replacement and maintenance of each high efficiency filter, the air in the sterile room shall be tested to ensure its performance.
    8.在送风和排风总管处应安装气密型密闭阀,必要时可完全关闭以进行室内化学熏蒸消毒。
    8. Air tight closed valves shall be installed at the main air supply and exhaust pipes, which can be completely closed if necessary for indoor chemical fumigation and disinfection.
    9.在无菌室及缓冲间内不应另外安装分体空调、暖气和电风扇等。
    9. Separate air conditioners, heating and electric fans shall not be installed in the sterile room and buffer room.
    无菌核心区及缓冲间内应保证工作照明,避免不必要的反光和强光。一、二级缓冲和核心区上方应分别配备一盏普通照明日光灯,其中核心区灯的开关控制安置在核心区门旁,一、二级缓冲的开关放置在靠近一级缓冲门的内走廊处。
    Working lighting shall be ensured in sterile core area and buffer room to avoid unnecessary reflection and strong light. 1、 A general lighting fluorescent lamp shall be equipped above the secondary buffer and the core area respectively. The switch control of the lamp in the core area shall be placed next to the door of the core area, and the switches of the primary and secondary buffers shall be placed in the inner corridor near the primary buffer door.
    以上的精彩内容来自:山东净之源净化工程有限公司无菌室装修的介绍及分享,更多内容请继续关注我们:http://www.jnyhrs.com
    The above wonderful content comes from the introduction and sharing of the decoration of the sterile room of Shandong jingzhiyuan purification Engineering Co., Ltd. please continue to pay attention to us for more content: http://www.jnyhrs.com