行业新闻
  • 您现在的位置:首页 > 新闻资讯 > 行业新闻 >
  • 无菌实验室装修设计要添加什么内容?
    来源:http://www.jnyhrs.com 浏览: 发布日期:2021-11-06
    1.工作室应矮小、平整,面积只需4米2左右,高2.2—2.3米,内部装修应平整、光滑,无凹凸不平或棱角等,四壁及屋顶应用不透水之材质,便于擦洗及杀菌。
    1. The studio shall be small and flat, with an area of only about 4m 2 and a height of 2.2-2.3m. The internal decoration shall be flat and smooth without unevenness or edges and corners. The four walls and roof shall be made of impermeable materials to facilitate scrubbing and sterilization.
    2.室内采光面积大,从室外应能看到室内情况。
    2. The indoor lighting area is large, and the indoor situation can be seen from the outside.
    3.为保证无菌室的洁净,无菌室周围需设缓冲走廊,走廊旁再设缓冲间,其面积可小于无菌室。
    3. In order to ensure the cleanness of the sterile room, a buffer corridor shall be set around the sterile room, and a buffer room shall be set next to the corridor, which can be smaller than the sterile room.
    4.无菌室、缓冲走廊及缓冲间均设有日光灯及供消毒空气用紫外灯,杀菌紫外灯离工作台以1米为宜 ,其电源开关均应设在室外。
    4. The sterile room, buffer corridor and buffer room are equipped with fluorescent lamp and ultraviolet lamp for disinfection air. The sterilization ultraviolet lamp should be 1m away from the workbench, and its power switch should be set outdoors.
    5.无菌室与缓冲间进出口应设拉门,门与窗平齐,门缝要封紧,两门应错开,以免空气对流造成污染。
    5. Sliding doors shall be set at the inlet and outlet of the sterile room and buffer room, the doors shall be flush with the windows, the door seams shall be sealed tightly, and the two doors shall be staggered to avoid pollution caused by air convection.
    6.无菌室的使用与管理
    6. Use and management of sterile room
    无菌室装修
    无菌室应保持清洁整齐,室内仅存放更必须的检验用具如酒精灯、酒精棉、火柴、镊子、接种针、接种环、玻璃铅笔等。
    The sterile room shall be kept clean and tidy, and only the most necessary inspection tools such as alcohol lamp, alcohol cotton, matches, tweezers, inoculation needle, inoculation ring, glass pencil, etc. shall be stored in the room.
    室内检验用具及凳桌等保持固定位置,不随便移动。
    Indoor inspection tools, benches and tables shall be kept in a fixed position and shall not be moved casually.
    每2—3周用2%石炭酸水溶液擦拭工作台、门、窗、桌、椅及地面,然后用3%石炭酸水溶液喷雾消毒空气,紫外灯杀菌 定期检查室内空气无菌状况,细菌数应控制在10个以下,发现不符合要求时,应立即彻底消毒灭菌。 无菌室无菌程度的测定方法:取普通肉汤琼脂平板、改良马丁培养基平板各3个(平板直径均9厘米),置无菌室各工作位置上,开盖曝露半小时,然后倒置进行培养,测细菌总数应置37℃温箱培养48小时;测霉菌数则应置27℃温箱培养5天。细菌`霉菌总数均不
    Every 2 to 3 weeks wipe the workbench, doors, windows, tables, chairs and ground with 2% carbonic acid solution. Then spray the air with 3% carbonic acid solution to disinfect the air. Finally, the ultraviolet lamp is sterilizing regularly to check the indoor air aseptic condition. The number of bacteria should be controlled below 10. Determination method of sterility degree in the sterile room: take 3 ordinary Broth Agar Plates and 3 modified Martin medium plates (both plates have a diameter of 9 cm), place them at each working position of the sterile room, open the cover and expose for half an hour, and then culture them upside down. The total number of bacteria measured should be cultured in a 37 ℃ incubator for 48 hours; To measure the number of molds, it should be cultured in a 27 ℃ incubator for 5 days. The total number of bacteria and molds is not
    无菌室杀菌前,应将所有物品置于操作之部位(待检物例外),然后打开紫外灯杀菌30分钟,时间一到,关闭紫外灯待用。
    Before sterilization in the sterile room, all articles shall be placed at the operation position (except for the articles to be tested), and then the ultraviolet lamp shall be turned on for sterilization for 30 minutes. Once the time is up, the ultraviolet lamp shall be turned off for standby.
    进入无菌室前,必须于缓冲间更换消毒过的工作服、工作帽及工作鞋。
    Before entering the sterile room, the sterilized work clothes, work hats and work shoes must be replaced in the buffer room.
    操作应严格按照无菌操作规定进行,操作中少说话,不喧哗,以保持环境的无菌状态。
    The operation shall be carried out in strict accordance with the aseptic operation regulations. During the operation, talk less and make no noise, so as to maintain the aseptic state of the environment.
    本文的内容是由无菌室装修给您提供,我们专注客户需求,不断的发展,为客户提供更多的服务,详情可参考我们的网站http://www.jnyhrs.com
    The content of this article is provided to you by the decoration of the sterile room. We focus on customer needs, continuous development and provide customers with more services. For details, please refer to our website http://www.jnyhrs.com